EV9797-91
MRS-20
Complete Mineral Reduction Water Processing System
B E N E F I T S
Improves equipment life and performance by
removing at least 90%+ of all dissolved solids
that cause scale build-up
Protects against taste and odor causing
contaminants while removing dirt, particulates
and dissolved minerals
Less frequent deliming of equipment means
reduced maintenance and service costs
Sanitary cartridge replacement is simple, quick
and clean. Internal filter parts are never exposed
to handling or contamination
Two-part design makes installation flexible, and
small footprint easily fits in any kitchen
Easy to operate system has no moving parts and
requires no electrical power
System includes mineral reduction processor,
carbon filter cartidge, reverse osmosis cartridge,
and storage tank
MRS-20 System: EV9797-91
797-92
4CB5 cartridge: EV9617-11
4CB5-MR cartridge: E17-17
No monitoring of grains per gallons is necessary.
System removes scale reducing minerals regardless
of the GPG
MR-20 Cartridge: EV9273-69
4MR-1 Cartridge: EV9273-69
A P P L I CA T I ON / S I Z I N G
I N S T A L L A T I ON T I P S
OP E R A T I ON T I P S
Choose a mounting location suitable to support
the full weight of the system when operating
Replace the 4CB5-MR carbon filter every 12
months. Change the 4MR-1 mineral reduction
cartridge every two years, or as needed
Mineral Reduction System for foodservice
applications
Mount system convenient to the post water
softener supply line and for routing the outlet and
drain lines
Ideal for: Flash steamers, conventional steamers,
cheese melters, combi-ovens and coffee/espresso
machines
Cartridge replacement schedules assume the
system is installed on softened water
The tank assemby may be mounted above, below
or alongside (preferred) of the water processor
assembly
Outlet Water Production: 25 gal. per day (54.5L)
@ 50 psig (340 kPa), 77°F (25°C) per NSF
Standard 58 testing. Water production depends
on supply water pressure and temperature
Uniquely designed for low volume applications
(approximately 25 gpd nominal consumption)
Install vertically with cartridges hanging down.
Allow 2-1/2" clearance below the cartridge for
easy cartridge replacement
Wastewater Production: 74 gal. per day (289L)
@ 50 psig (340 kPa), 77°F (25°C). Wastewater
drain line capacity: 3 gpm (21 Lpm) to open
atmosphere
The water inlet must supply a minimum of 0.5
gpm at 50-85 psi on a consistent basis
Storage Tank Capacity: 3 gallon tank; effective/
usable capacity: 2.5 gal. (9.5L)
Deliming of equipment prior to application is
recommended
|