DOUBLE BASKET DEEP
FRYER
OWNER’S MANUAL
Model K4320
120V., 60Hz., 1700 Watts
EURO-PRO Operating LLC
Boston, MA, 02465
1 (800) 798-7398
COPYRIGHT© EURO-PRO OPERATING LLC 2008
OPERATING INSTRUCTIONS
OPERATING INSTRUCTIONS cont.
Read all the sections of this booklet and follow all the instructions carefully.
Using Solid Fat
Warning: Do not put solid shortening in
Using for the First Time
Warning: Never immerse the control
the oil container or the frying basket.
panel in water or any other liquids.
Warning: Never plug in the control panel
when it is not installed in the fryer body
with heating element in the oil container.
Do not immerse the control panel, cord or
plug in water.
• If using solid vegetable shortening, melt
it first in a separate pan and then very
carefully pour the melted fat into the oil
container.
• Previously used solid vegetable
shortening which has curdled and
hardened in the oil container should be
removed from the oil container and
melted in a separate pan before reusing.
Warning: All components must be
completely dried before filling with oil
or using. Special care must be taken
to ensure the washable oil filter in the
lid is completely dry, otherwise the
filter will not function properly and may
lead to steam being trapped within the
fryer during use.
Fig. 4
Warning: This unit should not be used
to boil water.
Prior To First Use, Clean The Unit
Thoroughly
Warning: Never exceed "MAX" line when
filling the basket with food.
Warning: If you try to melt the solidified
fat in the oil container, there is a risk of
warm melted fat suddenly sputtering from
below through the still solid top layer of fat.
Therefore use only the following procedure:
Control Panel
Warning: Always let the fryer cool
completely for 2 hours before taking it apart
for cleaning. Never carry or move the
Deep Fryer with hot oil inside. Before
cleaning, always make sure the magnetic
power plug is not in the wall socket.
Filling the Stainless Steel Container
With Oil
Using the Deep Fryer
Warning: Never plug in the Deep Fryer
before filling with oil to specified level.
Always make sure control panel is securely
in place in the body and the heating
element is inside the oil in the container
before plugging in.
Warning: Never plug in the Deep Fryer
before filling with oil to specified level.
Always make sure control panel is
securely in place in the body and the
heating element is inside the oil in the
container before plugging in.
• Make sure the fat is at room
temperature. If the fat is very cold, there
is a greater risk of splashing.
• Using a fork, carefully make some holes
in the fat. Make sure the lid is securely
closed while fat is melting. Set
• All components with the exception of the
electrical parts, can be washed in warm
soapy water. Dry thoroughly before use.
• Use basket handles to remove the
frying baskets. Always make sure the
basket handles are securely attached to
the basket. To attach the handles to the
frying baskets, insert the metal part of
the handle inside the metal bracket on
the frying basket. Lift the handle up over
the basket to secure in place.
Important: Ensure the control panel is
fitted correctly to the main unit otherwise
the unit will not function. This is not a
defect. This product is fitted with a safety
interlock switch to prevent the unit from
turning on accidentally.
temperature dial to 320º F (160º C).
• Use blended vegetable oil, pure corn oil
or canola (rapeseed) oil. Do not use
olive oil, margarine, lard or drippings.
• The oil level must always be maintained
between the minimum marked inside the
oil container. Maximum oil capacity is 21
cups (5 liters). Check the oil level before
each use. For best results, keep the oil
close to the maximum level (21 cups/5
liters). Fig. 2
Installing the “Control Panel With
the Heating Element” Into its Place
• Lift up the Control Panel with Heating
Element.
• Insert the "Guide Edges" on the Control
Panel (Fig. 4) into the "Guide Rails"
mounted on the metal body. (Fig. 3)
• Slide the "Guide Edges" down till the
end.
Pre-Heating
Warning: Never plug in the Deep Fryer
before filling with oil. (See "Filling"
instructions on page 3.) Always unplug
the appliance when not in use.
(Fig. 1)
• Lift the control panel with heating
element out of its slots by pushing it up
from the bottom with one hand while
holding the body of the deep fryer with
your other hand.
• Make sure the oil level in the oil
container is between the "minimum "
and "maximum lines inside the oil
container. Do NOT exceed the "MAX"
line on the oil container when filling with
oil.
• The frying basket should not be immersed
in the oil during the pre-heating.
• Replace the lid cover.
• Never mix different oils and fats together.
Do not mix old and new oil.
Important Notice: The Automatic
Safety Interlock Switch ensures that the
unit will not operate unless the Control
Panel has been inserted into the "Guide
Rails" on the metal body correctly.
• Remove the oil container.
• Clean the oil container and the frying
baskets with hot water, dishwashing
liquid or other non-poisonous detergent
and non-abrasive sponge.
Guide Rails
• Plug the appliance into a 120-volt outlet.
• Turn the On/Off switch to the "ON"
position.
Fig. 3
• Select the desired temperature on the
temperature setting dial. (Fig. 5)
Fig. 2
Fig. 1
Back of Main Body
Fig. 5
3
4
OPERATING INSTRUCTIONS cont.
OPERATING INSTRUCTIONS cont.
Pre-Heating (cont.)
Frying Food
Frying Tips
• Do not mix different oils or new and
old oil together.
Filtering & Changing The Oil
• Always use the frying baskets to fry food.
• Always close the lid cover during frying.
• When the oil is pre-heated, ready
indicator light will come on it indicating
that the desired temperature is reached.
• Slowly lower the frying basket into the
hot oil. Lowering the frying basket too
quickly can result in the oil overflowing
and splashing.
• Make sure the deep fryer is unplugged
and the oil has cooled before cleaning
or storing the deep fryer.
Warning: In order to avoid injury or
burns, never touch any metal parts on the
deep fryer because they may be hot.
• Replace oil regularly. In general, oil
will be tainted fast when frying food
containing a lot of protein, (such as
poultry, meat and fish). When oil is
used mainly to fry potatoes and is
filtered after each use, it can be used
up to 8 to 10 times, but do not use
the same oil for more than 6 months.
• Always replace all oil as soon as it
starts foaming when heated or when
color becomes dark or when it has a
rancid smell or taste or becomes
syrupy.
• Make sure that the food to be fried is
dry.
• Remove loose ice from frozen food
before frying. Rinse and pat dry.
• To cook evenly, pieces should be the
same size and thickness.
• The oil does not need to be changed
after each use. In general, the oil will
be tainted rather quickly when frying
food containing a lot of protein (such
as poultry, meat or fish). When oil is
mainly used to fry potatoes and is
filtered after each use, it can be used 8
to 10 times. However, do not use the
same oil for longer than 6 months.
• To filter the oil first make sure the oil
has cooled and then empty the oil from
the oil container into another container
or bottle. Fig. 7
• Pre-heating the oil will take up to 15
minutes depending on the temperature
selected.
• The temperature indicator light will
come on when the temperature is set
and the deep fryer is “on” showing that
the heating element is in operation.
This light goes off when the set
temperature is reached. (Fig. 6) The
temperature light may go on and off
several times during frying. This
indicates that the temperature is being
thermostatically maintained.
• Replace the lid carefully.
• It is normal for steam to escape through
the sides of the lid while frying.
• Avoid standing too close to the deep
fryer while it is working.
Warning: When opening the lid cover
after frying, lift up the lid slightly, then wait
to allow steam to escape before opening
the lid completely. Keep face away from
unit to avoid burns caused by escaping
steam.
Wash and dry the oil container and
basket. Refill the oil container with the
oil, pouring the oil through a wire
strainer or paper filter. Fig. 8
Temperature
Indicator
Light
On/Off
Switch
At the End of Cooking
• Thicker pieces will take longer to
cook.
Warning: When you have finished frying,
always turn the temperature setting dial to
lowest position, turn off power switch and
unplug the deep fryer from wall outlet. To
avoid injury or burns, do not touch any
metal surfaces as they are hot.
Important: When frying frozen food
such as French Fries in the large
frying basket, you should not exceed
1.25 lb. (568 gr.). For best results,
limit quantity to 1 Lb. (454 gr.) or
less.
Fig. 6
Filling the Frying Basket
Fig. 7
Fig. 8
• Set the temperature setting dial to the
lowest position, (turn fully counter
clockwise.).
• Turn On/Off switch to the "OFF" position.
• Unplug the main cord from the wall
socket.
• Lift up the lid cover slowly and wait to
allow steam to escape before opening
the lid cover completely.
• Lift up the frying baskets by the handle.
Place it (them) on the oil container and
allow the food to drain for a minute.
• Once the oil has drained from the
frying basket, the basket may be lifted
off and the food served.
• Do not fill the frying basket when it is
immersed in oil.
• Place the food in the frying basket. Do
not overfill it and never exceed the
maximum quantities. For optimum
results and shorter frying time, basket
should be only 1/2 full.
• The large basket has approximately
1.5 lb. food capacity. It will hold 3-4
average size pieces of chicken. The
small baskets should be filled ONLY till
the MAX line on the fryer basket.
• Do not fill the baskets higher than the
MAX line on the baskets with frozen
food.
Temperature Settings
The following cooking times reflect only the approximate time needed to fry one
basket 1/2 full. The exact time may be different depending on actual quantity,
personal cooking preferences, size and thickness of pieces, etc...
In general, use lower settings for delicate foods (vegetables, fish) and higher settings
for frozen foods, French Fries and Chicken.
Food
French Fries
Cooking Time
Temperature
6-9 minutes
3-5 minutes
6-8 minutes
13-20 minutes
3 minutes
375°F
320°F
350°F
350°F
320°F
320°F
320°F
350°F
350°F
320°F
Fish Fillets
Chicken Fingers
Chicken Pieces
Fried Zucchini
Fried Mushrooms
Onion Rings
Donuts
Warning: When frying foods, always
remove the frying baskets from the deep
fryer before filling with food because oil will
spatter and cause burns. Be especially
cautious when frying frozen foods.
Caution: When frying frozen foods such as
French Fries, you should not exceed
1.25 Lb. (564 gr.) in the large basket. For best
crispy results limit quantity to 1 Lb. (454 gr.).
Clean off any ice from frozen food prior to
frying. Failure to do so may cause fryer to
overflow when food is placed in oil.
Warning: Always let the deep fryer
cool completely (approximately 2 hours)
before cleaning or storing. Never carry or
move the deep fryer with hot oil inside.
3 minutes
3 minutes
3-5 minutes
4 minutes
Apple Beignets
Shrimp
4-6 minutes
5
6
K4320
OPERATING INSTRUCTIONS cont.
Cleaning Instructions
Detachable Magnetic Power Cord
ONE (1) YEAR LIMITED WARRANTY
Warning: Always remove the plug
from the wall socket before cleaning.
Allow the deep fryer and the oil to cool
completely (approximately 2 hours)
before cleaning. Never immerse the
control panel, cord or plug in water or
any other liquid.
Your
specifically designed with your safety in
mind. has incorporated a
Deep Fryer has been
EURO-PRO Operating LLC warrants this product to be free from defects in material and
workmanship for a period of one (1) year from the date of the original purchase, when utilized for
normal household use, subject to the following conditions, exclusions and exceptions.
If your appliance fails to operate properly while in use under normal household conditions within
the warranty period, return the complete appliance and accessories, freight prepaid. For Customer
unique detachable power supply cord.
This power supply cord cord is
designed to “Break Away” from the fryer
body in the event that the supply cord is
inadvertently pulled. This is intended to
prevent the tipping of the appliance and
hazardous spillage of hot oil.
The female receptacle portion of the
power supply cord is permanently
attached to the rear of the the control
panel.
To connect the male power cord plug to
the female receptacle on the appliance,
orient the male plug so that it mates
with the female receptacle. The male
plug can only be inserted one way. If
the male plug will not go into the
receptacle on the appliance, rotate the
male plug 180°
If the appliance is found to be defective in material or workmanship, EURO-PRO Operating LLC
will repair or replace it free of charge. Proof of purchase date and $ 14.95 to cover the cost of
return shipping and handling must be included. *
• Follow the cleaning instructions on
page 3. (Before using for the First
Time)
• Never immerse the control panel, cord
or plug in water or any other liquid.
• Do not place the control panel, cord or
plug in the dishwasher.
• Clean the control panel only with a
damp cloth.
• The oil container, frying basket, lid
cover and filter can be washed in the
dishwasher.
• The body of the deep fryer can be
washed in warm soapy water. Do not
put the body of the deep fryer in the
dishwasher.
• Any other servicing should be
performed by EURO-PRO Operating
LLC.
The liability of EURO-PRO Operating LLC is limited solely to the cost of the repair or replacement
of the unit at our option. This warranty does not cover normal wear of parts and does not apply to
any unit that has been tampered with or used for commercial purposes. This limited warranty does
not cover damage caused by misuse, abuse, negligent handling or damage due to faulty
packaging or mishandling in transit. This warranty does not cover damage or defects caused by
or resulting from damages from shipping or repairs, service or alterations to the product or any of
its parts, which have been performed by a repair person not authorized by EURO-PRO Operating
LLC.
This warranty is extended to the original purchaser of the unit and excludes all other legal and/or
conventional warranties. The responsibility of EURO-PRO Operating LLC if any, is limited to the
specific obligations expressly assumed by it under the terms of the limited warranty. In no event is
EURO-PRO Operating LLC liable for incidental or consequential damages of any nature
whatsoever. Some states/provinces do not permit the exclusion or limitation of incidental or
consequential damages, so the above may not apply to you.
This warranty gives you specific legal rights, and you may also have other rights which vary from
state to state or province to province.
IMPORTANT: Should the male plug
become detached from the appliance
during use, it is important to:
1. Unplug the power cord from the wall
outlet.
*Important: Carefully pack item to avoid damage in shipping. Be sure to include proof of
purchase date and to attach tag to item before packing with your name, complete address
and phone number with a note giving purchase information, model number and what you
believe is the problem with item. We recommend you insure the package (as damage in
shipping is not covered by your warranty). Mark the outside of your package “ATTENTION
CUSTOMER SERVICE”. We are constantly striving to improve our products, therefore the
specifications contained herein are subject to change without notice.
2. Turn off the appliance at the control
panel.
3. Re-attach the power cord to the
appliance.
4. Re-connect to power outlet.
5. Turn the appliance back on.
------------------------------------------------------------------------------------------------------------------------------------------------------------
OWNERSHIP REGISTRATION CARD
FOR CANADIAN CONSUMERS ONLY
Please fill out and mail the product registration card within ten (10) days of purchase in order to
validate the foregoing Limited Warranty. The registration will enable us to contact you in the
unlikely event of a product safety notification. By returning this card you acknowledge to have read
and understood the instructions for use, and warnings set forth in the accompanying instructions.
RETURN TO EURO-PRO Operating LLC, 4400 Bois Franc, St. Laurent, Qc, H4S 1A7
K4320
______________________________________________________________________
Appliance model
______________________________________________________________________
Date purchased
Name of store
______________________________________________________________________
Owner’s name
______________________________________________________________________
Address
City
Prov.
Postal code
Printed in China
7
8
|