R
Trademark
Operator’s Manual
Manual del Operador
Manuel de L’utilisateur
TWISTER SB180
SB30
IMPORTANT MANUAL -- Do not throw away
MANUAL IMPORTANTE -- No lo descarte
MANUEL IMPORTANT -- À Conserver
WARNING: Read the operator’s manual and follow all
warnings and safety instructions. Failure to do so can
result in serious injury. Always wear eye protection.
ADVERTENCIA: Lea el manual del operador y siga todas
las advertencias e instrucciones de seguridad. El no
hacerlo puede resultar en lesiones graves.
AVERTISSEMENT: Lire le manuel de l’utilisateur et bien
respecter tous les avertissements et toutes les instructions
de sécurité. Tout défaut de le faire pourrait entraîner des
blessures graves.
Electrolux Home Products, Augusta, GA 30907
WCI Outdoor Products, Inc.
530088756
6/28/00
MAINTAIN YOUR UNIT PROPERLY
D Have all maintenance other than the rec-
ommended procedures described in the
Operator’s Manual performed by your
Service Dealer.
ASSEMBLY
PREPARATION
D Disconnect spark plug before performing
maintenance except for carburetor adjust-
ments.
WARNING: If you receive your unit
assembled, check each step to insure your
unit is properly assembled. Follow all safety
information in the manual and on the unit.
D Use only recommended WEED EATER
replacement parts; use of any other parts
may void your warranty and cause dam-
age to your unit.
D No tools are required for assembly.
BLOWER TUBE ASSEMBLY
D Assemble the blower tube and nozzle to
the unit (turn clockwise to tighten).
D Empty the fuel tank before storing the unit.
Use up fuel left in carburetor by starting the
engine and letting it run until it stops.
D Do not use any accessory or attachment
other than those recommended by the
manufacturer for use with your unit.
D Do not store the unit or fuel in a closed area
where fuel vapors can reach sparks or an
open flame from water heaters, electric
motors or switches, furnaces, etc.
Blow
Outle
Blower
Tube
Nozzle
D Store in a dry area out of reach of children.
SPECIAL NOTICE: For users on U.S.
Forest Land and in some states, including
California(Public Resources Codes 4442
and 4443), Idaho, Maine, Minnesota, New
Jersey, Oregon, and Washington: Certain in-
ternal combustion engines operated on for-
est, brush, and/or grass covered land in the
above areas are required to be equipped
with a spark arrestor, maintained in effective
working order, or the engine must be con-
structed, equipped, and maintained for the
prevention of fire. Check with your state or
local authorities for regulations pertaining to
these requirements. Failure to follow these
requirements is a violation of the law. This
unit is not factory equipped with a spark ar-
restor; however, a spark arrestor is available
as an optional part. If a spark arrestor is re-
quired in your area, contact your Authorized
Service Dealer for the correct kit. The spark
arrestor, blower tubes, and nozzles must be
assembled to the unit to be in full compliance
with the regulations.
NOTE: An optional vacuum kit is available
for your unit. See your local retailer or call
1--800--554--6723 for details.
USING YOUR UNIT
YOU MUST make sure the tubes are secure
before using the unit.
Eye
Protection
SPECIAL NOTICE: Exposure to vibra-
tions through prolonged use of gasoline
powered hand tools could cause blood ves-
sel or nerve damage in the fingers, hands,
and joints of people prone to circulation dis-
orders or abnormal swelling. Prolonged use
in cold weather has been linked to blood ves-
sel damage in otherwise healthy people. If
symptoms occur such as numbness, pain,
loss of strength, change in skin color or tex-
ture, or loss of feeling in the fingers, hands, or
joints, discontinue the use of this tool and
seek medical attention. An antivibration sys-
tem does not guarantee the avoidance of
these problems. Users who operate power
tools on a continual and regular basis must
monitor closely their physical condition and
the condition of this tool.
BLOWER
FUELING
This engine is certified to operate on un-
leaded gasoline. Gasoline must be mixed
with a good quality 2-cycle air-cooled engine
oil designed to be mixed at a ratio of 40:1.
Poulan/Weed Eater brand oil is recom-
mended. (A 40:1 ratio is obtained by mixing
3.2 ounces of oil with 1 gallon of unleaded
gasoline). When mixing fuel follow the
instructions printed on the container. Always
read and follow safety rules under HANDLE
FUEL WITH CAUTION in the SAFETY
RULES section.
-- 3 --
D Move choke to HALF CHOKE position.
D Pull starter rope handle sharply until en-
gine runs, but no more than 6 pulls.
NOTE: If engine has not started after 6
pulls, repeat all of the above steps.
D Allow engine to run for 10 to 15 seconds,
then move choke to OFF CHOKE position.
D Squeeze and release the throttle trigger to
release the throttle lock.
STARTING
TO STOP THE ENGINE:
D The ON/STOP switch is used to stop the en-
gine. The switch stays in the ON position.
To stop engine, press and hold the switch
in the STOP position until the engine
comes to a complete stop.
NOTE: If engine dies with choke at OFF
CHOKE position, move the choke to the
HALF CHOKE position and pull the starter
rope handle 5 more times. If engine does not
start and operate properly, refer to CARBU-
RETOR ADJUSTMENTS.
BEFORE STARTING THE ENGINE:
D Fuel the engine. Move at least 10 feet (3
meters) away from the fueling site.
D Hold the unit in the starting position as
shown. Make sure the blower end is di-
rected away from people, animals, glass,
and solid objects.
D To stop engine, press and hold switch in
the OFF position.
STARTING A WARM ENGINE:
D Move choke to HALF CHOKE position.
D Activate the throttle lock.
D Pull starter rope handle sharply until en-
gine runs, but no more than 6 pulls.
D Move choke to OFF CHOKE position.
Then, squeeze and release the throttle
trigger to release the throttle lock.
STARTING
POSITION
NOTE: If engine does not run after 5 pulls, it
is probably flooded. Wait a few minutes and
repeat procedure with choke at OFF
CHOKE.
D To stop engine, press and hold switch in
the OFF position.
WARNING: When starting engine,
hold the unit as illustrated. Do not set unit on
any surface except a clean, hard area when
starting engine or while engine is running.
Debris such as gravel, sand, dust, grass,
etc. could be picked up by the air intake and
thrown out through the discharge opening,
damaging the unit or property, or causing se-
rious injury to bystanders or the operator.
DIFFICULT STARTING (or starting a
flooded engine)
Flooded engines can be started by placing
choke lever in the OFF CHOKE position. Ac-
tivate the throttle lock, then, pull rope until en-
gine starts. After the engine starts, squeeze
and release the throttle trigger to release the
throttle lock and allow engine to idle. Starting
could require pulling the starter rope handle
many times depending on how badly unit is
flooded. If unit still doesn’t start, refer to the
TROUBLESHOOTING TABLE or call
1--800--554--6723.
Switch
Throttle
Trigger
Throttle
Lock
SERVICE
Choke Lever
(shown in HALF CHOKE position)
We recommend all service and adjustments
not listed in this manual be performed by an
Authorized Service Dealer.
STARTING A COLD ENGINE (or a
warm engine after running out of
fuel)
CARBURETOR ADJUSTMENTS
Your carburetor is equipped with limiter
caps. Carburetor adjustment is a compli-
cated task. We recommend that you take
your unit to an Authorized Service Dealer.
Damage will occur if you turn the needles be-
yond the limiter stops.
D Move choke to FULL CHOKE position.
D Activate the throttle lock as follows:
D squeeze and hold throttle trigger;
D press and hold throttle lock, then
D release the throttle trigger
D Pull starter rope handle sharply until en-
gine attempts to run, but NO MORE THAN
6 PULLS.
NOTE:: The engine may sound as if it is try-
ing to start before the 6th pull. This sound
may be hard to hear. If so, go to the next step
immediately.
SPARK PLUG
Replace spark plug yearly using a Champion
RCJ-8Y spark plug. Spark plug gap is .025”.
IGNITION TIMING
Ignition timing is fixed, nonadjustable.
-- 4 --
TROUBLESHOOTING TABLE
WARNING: Always stop unit and disconnect spark plug before performing any of the
recommended remedies below other than remedies that require operation of the unit.
TROUBLE
Engine will not
start.
CAUSE
REMEDY
S Engine flooded.
S See “Starting Instructions.”
S Fill tank with correct fuel mixture.
S Install new spark plug.
S Fuel tank empty.
S Spark plug not firing.
S Fuel not reaching carburetor.
S Check for dirty fuel filter; replace.
Check for kinked or split fuel line;
repair or replace.
S Compression low.
S Contact Authorized Service Dealer.
S See “Carburetor Adjustments.”
S Contact Authorized Service Dealer.
S Contact Authorized Service Dealer.
Engine will not S Carburetor requires adjustment.
S Crankshaft seals worn.
idle properly.
S Compression low.
Engine will not S Air filter dirty.
S Clean or replace air filter.
S Spark plug fouled.
S Clean or replace spark plug; re-gap.
S See “Carburetor Adjustments.”
S Contact Authorized Service Dealer.
S Contact Authorized Service Dealer.
accelerate,
S Carburetor requires adjustment.
lacks power, or
dies under a
load.
S Carbon build up.
S Compression low.
S Choke partially on.
S Adjust choke.
Engine
S Fuel mixture incorrect.
S Empty fuel tank and refill with
correct fuel mixture.
smokes
excessively.
S Air filter dirty.
S Carburetor requires adjustment.
S Clean or replace air filter.
S See “Carburetor Adjustments.”
S See “Fueling Your Unit.”
S Fuel mixture incorrect.
S Spark plug incorrect.
S Carburetor requires adjustment.
S Carbon build up.
Engine
runs hot.
S Replace with correct spark plug.
S See “Carburetor Adjustments.”
S Contact Authorized Service Dealer.
tune-ups, spark plugs, filters, starter ropes,
starter springs, cutting line, or rotating head
parts that will wear and require replacement
with reasonable use during the warranty pe-
riod. This warranty does not cover predeliv-
ery setup or normal adjustments explained in
the operator’s manual.
Need Assistance? Call 1-800-554-6723.
Need a Service Part? Contact your retailer.
NEED ASSISTANCE?
LIMITED WARRANTY
THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS, AND YOU MAY HAVE
OTHER RIGHTS WHICH VARY FROM
STATE TO STATE.
ELECTROLUX HOME PRODUCTS, Divi-
sion WCI Outdoor Products, Inc., warrants
to the original purchaser that each new
Weed Eater brand gasoline tool or attach-
ment is free from defects in material and
workmanship and agrees to repair or replace
under this warranty any defective gasoline
product or attachment as follows from the
original date of purchase.
2 YEARS -- Parts and Labor, when used for
household purposes.
60 DAYS -- Parts and Labor, when used for
commercial, professional, or income pro-
ducing purposes.
NO CLAIMS FOR CONSEQUENTIAL OR
OTHER DAMAGES WILL BE ALLOWED,
AND THERE ARE NO OTHER EXPRESS
WARRANTIES EXCEPT THOSE EX-
PRESSLY STIPULATED HEREIN.
SOME STATES DO NOT ALLOW LIMITA-
TIONS ON HOW LONG AN IMPLIED WAR-
RANTY LASTS OR THE EXCLUSION OR
LIMITATIONS OF INCIDENTAL OR CON-
SEQUENTIAL DAMAGES, SO THE
ABOVE LIMITATIONS OR EXCLUSION
MAY NOT APPLY TO YOU.
30 DAYS -- Parts and Labor, if used for rental
purposes.
ELECTROLUX HOME PRODUCTS’ policy
is to continuously improve its products.
Therefore, ELECTROLUX HOME PRO-
DUCTS reserves the right to change, mod-
ify, or discontinue models, designs, specifi-
cations, and accessories of all products at
any time without notice or obligation to any
purchaser.
This warranty is not transferable and does
not cover damage or liability caused by im-
proper handling, improper maintenance, or
the use of accessories and/or attachments
not specifically recommended by ELEC-
TROLUX HOME PRODUCTS for this tool.
Additionally, this warranty does not cover
-- 5 --
1--800--554--6723.
WARRANTY COM-
U.S. EPA
MENCEMENT DATE: The warranty period
begins on the date the lawn and garden
equipment engine is purchased. LENGTH
OF COVERAGE: This warranty shall be for
a period of two years from the initial date of
purchase. WHAT IS COVERED: REPAIR
OR REPLACEMENT OF PARTS. Repair or
replacement of any warranted part will be
performed at no charge to the owner at an
approved POULAN/WEED EATER servic-
ing center. If you have any questions regard-
ing your warranty rights and responsibilities,
you should contact your nearest authorized
service center or call POULAN/WEED EAT-
ER at 1--800--554--6723 WARRANTY PE-
RIOD: Any warranted part which is not
scheduled for replacement as required
maintenance, or which is scheduled only for
regular inspection to the effect of “repair or
replace as necessary” shall be warranted for
2 years. Any warranted part which is sched-
uled for replacement as required mainte-
nance shall be warranted for the period of
time up to the first scheduled replacement
point for that part. DIAGNOSIS: The owner
shall not be charged for diagnostic labor
which leads to the determination that a war-
ranted part is defective if the diagnostic work
is performed at an approved POULAN/
WEED EATER servicing center. CONSE-
QUENTIAL DAMAGES: POULAN/WEED
EATER may be liable for damages to other
engine components caused by the failure of
a warranted part still under warranty. WHAT
IS NOT COVERED: All failures caused by
abuse, neglect, or improper maintenance
are not covered. ADD--ON OR MODIFIED
PARTS: The use of add--on or modified parts
can be grounds for disallowing a warranty
claim. POULAN/WEED EATER is not liable to
cover failures of warranted parts caused by
the use of add--on or modified parts. HOW
TO FILE A CLAIM: If you have any ques-
tions regarding your warranty rights and re-
sponsibilities, you should contact your near-
est authorized service center or call POU-
LAN/WEED EATER at 1--800--554--6723 .
WHERE TO GET WARRANTY SERVICE:
Warranty services or repairs shall be provided
at all POULAN/WEED EATER service cen-
ters. call: 1--800--554--6723 MAINTENANCE,
REPLACEMENT AND REPAIR OF EMIS-
SION RELATED PARTS: Any POULAN/
WEED EATER approved replacement part
used in the performance of any warranty
maintenance or repair on emission related
parts will be provided without charge to the
owner if the part is under warranty. EMIS-
SION CONTROL WARRANTY PARTS
LIST: Carburetor, Ignition System: Spark
Plug (covered up to maintenance schedule),
Ignition Module. MAINTENANCE STATE-
MENT: The owner is responsible for the per-
formance of all required maintenance as de-
fined in the owner’s manual.
EMISSION CONTROL
WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OB-
LIGATIONS: The U. S. Environmental
Protection Agency and POULAN/WEED
EATER, DIVISION OF WCI OUTDOOR
PRODUCTS are pleased to explain the
emissions control system warranty on your
lawn and garden equipment engine. All new
utility and lawn and garden equipment en-
gines must be designed, built, and equipped
to meet the stringent anti--smog standards.
POULAN/WEED EATER must warrant the
emission control system on your lawn and
garden equipment engine for the periods of
time listed below provided there has been no
abuse, neglect, or improper maintenance of
your lawn and garden equipment engine.
Your emission control system includes parts
such as the carburetor and the ignition sys-
tem. Where a warrantable condition exits,
POULAN/WEED EATER will repair your
lawn and garden equipment engine at no
cost to you. Expenses covered under war-
ranty include diagnosis, parts and labor.
MANUFACTURER’S WARRANTY COV-
ERAGE: If any emissions related part on
your engine (as listed under Emissions Con-
trol Warranty Parts List) is defective or a de-
fect in the materials or workmanship of the
engine causes the failure of such an emis-
sion related part, the part will be repaired or
replaced by POULAN/WEED EATER.
OWNER’S WARRANTY RESPONSIBILI-
TIES: As the lawn and garden equipment en-
gine owner, you are responsible for the per-
formance of the required maintenance listed
in your Owner’s Manual. POULAN/WEED
EATER recommends that you retain all re-
ceipts covering maintenance on your lawn
and garden equipment engine, but POU-
LAN/WEED EATER cannot deny warranty
solely for the lack of receipts or for your fail-
ure to ensure the performance of all sched-
uled maintenance. As the lawn and garden
equipment engine owner, you should be
aware that POULAN/WEED EATER may
deny you warranty coverage if your lawn and
garden equipment engine or a part of it has
failed due to abuse, neglect, improper main-
tenance, unapproved modifications, or the
use of parts not made or approved by the
original equipment manufacturer. You are
responsible for presenting your lawn and
garden equipment engine to a POULAN/
WEED EATER authorized repair center as
soon as a problem exists. Warranty repairs
should be completed in a reasonable amount
of time, not to exceed 30 days. If you have
any questions regarding your warranty
rights and responsibilities, you should con-
tact your nearest authorized service center
or call POULAN/WEED EATER at
-- 6 --
|